Chương 27: The First Foundation

The morning sun cast a pale light over the ruined village, but for the first time in weeks, the men standing in the snow were not shivering from the cold. They were frozen in absolute shock. Giles stood at the front of the group of carpenters, his wood-axe hanging limply from his hand. His jaw was slightly open. When they had left the village at dusk the previous day, they had barely managed to pry a dozen frozen planks off a single ruined hut. It was backbreaking, miserable work.

Giles had estimated it would take them a full week just to salvage enough timber for the first Winter Cabin. Now, the entire center of the village street was transformed. Eight ruined houses were completely gone. In their place was a massive, perfectly organized stacks of seasoned oak and pine planks. The wood was sorted precisely by length and thickness.

Next to the timber was a large wooden barrel filled to the brim with hundreds of rusted iron nails, each one pulled clean from the wood without splitting the planks.

"By the gods," Old Miller whispered, his breath pluming in the air.

"Did... did the mages do all this? In a single night?" Giles slowly walked up to the nearest stack of wood. He ran his thick, calloused hand over the top plank. It was perfectly intact. There were no hasty crowbar marks, no splintered edges from careless pulling.

"They didn't just tear the houses down," Giles said, his voice filled with a mixture of deep respect and lingering fear.

"They dismantled them. Piece by piece. I have never seen men work with such terrifying speed. The Lord's retainers... they truly are monsters of labor."

"Efficient would be a better word," a calm voice called out. The men turned around. Jack was walking down the mountain path, leaning heavily on his cane. Karen walked closely beside him, carrying a large ledger book Jack had repurposed from the castle library. Jack looked extremely pale, and dark shadows were under his eyes from the mental strain of managing twenty-one skeletons the night before. But he carried himself with a sharp energy.

The survival of his people was depending on these cabins, and the Stone-Sickness in the Great Hall was a ticking clock.

"The wood is ready," Jack said, stopping in front of the men.

"My retainers have done the heavy lifting. Now it is your turn to build."

"We will start framing the first house immediately, Lord Jack," Giles said, pulling his cap down over his head. He turned to the men.

"Alright, listen up! I want three men measuring the base, and four men cutting the joints. We build the four walls first, then we raise them—""No," Jack interrupted. Giles stopped, looking at the young lord in confusion.

"My Lord?" Jack stepped forward, tapping his cane against the packed snow.

"If you build these cabins the traditional way, one wall at a time, we will not finish before the sickness takes the children in the hall. We are going to change how you work. We are not going to build a house, Giles. We are going to build parts." Jack opened the ledger Karen was holding. He had spent his few hours of sleep designing an assembly line, applying a strict, organized logic to medieval carpentry.

"We are dividing the labor," Jack instructed, pointing to the men.

"Giles, you and the two strongest men will do nothing but hammer the structural joints. You do not fetch nails. You stay in one spot and assemble." He turned to the younger men and the older boys who had followed them down from the castle.

"You are the runners. Your only job is to carry the cut planks from these stacks directly to Giles. Keep his hands full of wood at all times." Finally, Jack looked at Old Miller and a group of village women who were standing nearby with heavy barrels of collected ash and sawdust.

"As soon as Giles secures the inner and outer planks of the double-wall, you step in," Jack told them.

"Do not wait for the roof. Pour the ash and sawdust directly into the gaps between the walls. Pack it down tight with wooden poles. The moment a wall section goes up, it gets insulated." Giles frowned slightly.

"Lord Jack, with all due respect, that isn't how carpenters work. It feels chaotic."

"It is an assembly line," Jack said firmly.

"It removes the wasted time of walking back and forth. Trust the system. Your daily porridge and your coal depend on it. Now, begin." The first hour was a mess. The men were used to starting a project and seeing it through to the end individually. The runners bumped into each other, the women spilled ash in the snow, and Giles kept instinctively dropping his hammer to go fetch his own wood. But Jack stood in the center of the worksite, directing the flow of traffic like a warehouse manager.

He barked orders, corrected mistakes, and kept the materials moving. By the third hour, the chaos vanished. A natural, flowing rhythm took over the village street. The runners grabbed the planks from the perfectly sorted piles and handed them off. Giles and his men hammered the iron nails with a rapid, unrelenting pace. The moment a section of the double-wall was secured, the women stepped in, dumping buckets of dry ash and sawdust into the gap, packing the insulation down tight to trap the dead air.

The speed of construction doubled. Then, it tripled. By midday, the entire square foundation and the four thick, insulated double-walls of the first Winter Cabin were already standing. The villagers were panting, their faces red and slick with sweat despite the freezing winter air. But the atmosphere was not miserable. A strange, joyful energy had taken hold of the worksite. Old Miller actually started humming a low working tune as he packed the ash into the walls.

Soon, the runners were whistling along, their boots crunching in the snow in time with the music. Love this novel? Read it on Royal Road to ensure the author gets credit. Jack watched them from the sidelines, leaning on his cane. A genuine smile touched his lips. His organized system was working flawlessly. The next two days were a blur of rapid construction. The steep-pitched roof was raised.

The angle was sharp, designed to force the winter snow to slide right off the wooden shingles rather than crush the building under its weight. The women finished packing the walls, sealing the top gaps with thick tar to ensure the insulation remained completely dry. But the true genius of the Winter Cabin was not in the walls. It was in the floor. On the afternoon of the third day, Jack was inside the half-finished prototype cabin.

The air inside was completely still, blocked from the howling wind by the thick, double-timber walls, but it was still bitterly cold. Barnaby the Blacksmith walked through the doorway. He was carrying a massive iron grate and several thick iron pipes.

"I brought the metal, Lord Jack," Barnaby grunted, setting the iron down on the dirt floor with a loud clang.

"Exactly to your drawings."

"Excellent work, Barnaby," Jack said, stepping away from the wall. The center of the cabin floor was dug out. Giles and his men had laid a foundation of flat river stones, creating a large, circular hearth in the middle of the room. But unlike a normal hearth, this one had four distinct, shallow trenches radiating outward from the center, running like spokes on a wheel directly beneath the area where the wooden floorboards would soon be laid. Jack knelt down with difficulty, pointing to the trenches.

"We place the flat stones over these shallow paths," Jack instructed Barnaby.

"When the fire burns in the central hearth, the iron grate you forged will be on top, holding the coal. But the smoke and the heat will not just rise straight up to the ceiling." Barnaby knelt beside him, his experienced eyes tracing the stone paths. He understood heat better than any man in the valley.

"The draft from the chimney will pull the heat outward first," Barnaby observed, tracing his thick finger along one of the trenches.

"It will force the hot air to travel under the floorboards before it vents out the side walls."

"Exactly," Jack nodded.

"It is a hypocaust system. The stone channels will absorb the extreme heat of the exhaust. Instead of losing all our warmth straight out the roof, the floor itself will become a massive radiator. It will heat the room from the bottom up." Barnaby picked up one of the flat paving stones and set it carefully over the trench, securing it with a thick layer of wet clay. The blacksmith worked in silence for a few minutes, his hands moving with surprising delicacy as he fitted the stones together.

Finally, he sat back on his heels and looked at Jack.

"This isn't magic, Lord Jack," Barnaby said quietly, his eyes studying the young lord's pale face. Jack raised an eyebrow.

"No. It is just stone and airflow."

"That is my point," Barnaby said, wiping his soot-stained hands on his apron.

"A mage relies on his core. A noble relies on his gold. But this... this is pure, brilliant craftsmanship. The double walls, the ash insulation, the underfloor heating. A man doesn't just invent these things out of thin air while sitting in a castle. Where did you learn to build like this, My Lord?" Jack looked down at the stone hearth.

"The castle library is very large," Jack said softly.

"While everyone else was focused on swords and magic, I spent my time reading old books on foundations and masonry. The people who built this castle hundreds of years ago understood how to fight the weather. I simply applied their lessons." Barnaby didn't press the issue. He simply nodded, picking up another stone.

"Well, whoever wrote those books knew his trade. This cabin will hold heat better than my own forge." By the time the sun set on the third day, the prototype Winter Cabin was completely finished. The wooden floorboards were nailed into place over the stone heating channels. The door was hung on its iron hinges, and the glass windows salvaged from the castle were sealed tight with tar. The real test had finally arrived. The air outside was dropping to a lethal temperature. The winter night was clear and sharp.

Jack stood in the center of the freezing cabin. Beside him stood Giles, Karen, and Barnaby. But they were not alone. Jack had chosen the first family to test the prototype. It was Elric, his wife, and their young, seven-year-old son—the same family who had been involved in the bitter argument over the dropped boots in the Great Hall three days ago. Elric's wife was holding her son tightly against her chest. All three of them were shivering violently, their breath forming thick white clouds in the dark room.

The cabin blocked the wind, but the temperature inside was still freezing.

"It is very cold, Lord Jack," Elric whispered, his teeth chattering loudly. He looked around the dark, empty wooden room with obvious doubt.

"It will not be cold for long," Jack promised. He pointed his cane toward the central stone hearth in the middle of the floor.

"Light it, Elric." Elric stepped forward. He carried a small woven basket holding exactly ten lumps of Jack's premium, black anthracite coal. It was a meager amount of fuel, barely enough to keep a normal, drafty hut warm for a single hour. Elric placed the coal onto the heavy iron grate. He used a flint and steel, striking a spark into a small pile of dry wood shavings beneath the coal. The shavings caught. The small orange flame licked upward, catching the edges of the dense black rocks.

Everyone in the room stood in complete silence, watching the fire. At first, nothing happened. The cabin remained bitterly cold. Elric's wife pulled her patched wool coat tighter around her shivering son. Giles shifted nervously on his feet. Five minutes passed. The coal began to glow with a fierce, bright white heat.

"Wait," Karen whispered, looking down at her boots. Jack felt it too. It was subtle at first. The freezing chill rising from the ground slowly vanished. Then, the heat arrived. The hot exhaust from the glowing coal was being pulled outward by the drafts, flowing directly through the stone channels beneath the wooden floorboards. The stones absorbed the intense heat, and within minutes, the entire floor of the cabin began to radiate warmth. The heat rose naturally, filling the room.

But unlike the drafty huts of the past, the heat had nowhere to escape. The thick layers of packed ash and sawdust inside the double-walls acted as a perfect, impenetrable barrier. The heat bounced off the walls and stayed inside. Ten minutes later, the air in the cabin was warm. Twenty minutes later, it was sweltering.

"By the gods," Giles breathed. The big carpenter unbuttoned the top of his heavy winter coat, his eyes wide in utter disbelief. The cabin was hotter than the Great Hall had ever been, and it was achieving this massive temperature using only ten small lumps of coal. The efficiency was staggering. Elric stood near the hearth, his hands hovering over the warm floorboards. He looked at the glowing fire, and then he looked at his wife. The young mother was no longer shivering.

Her tense, fearful posture completely melted away. She slowly reached down and untied the thick wool scarf from her son's neck. The boy giggled, wriggling out of his winter coat entirely, leaving him in just his simple linen shirt. He wasn't cold. He was perfectly, completely warm. Elric's wife looked at her son, and then she looked at Jack. Tears welled up in her eyes, spilling over her cheeks. She didn't say a word. She simply fell to her knees on the warm wooden floor and wept.

They were not tears of sorrow or pain. They were tears of absolute, overwhelming relief. They had a home. A real, safe home that the winter could not touch. Jack stood near the door, leaning on his cane. The intense heat of the cabin felt wonderful against his own frail joints. He watched the family huddle together in the warmth, feeling a profound sense of accomplishment settle deep in his chest.

"One down," Jack said quietly, turning to Giles and Barnaby.

"We need four more just like it. The moment they are built, we empty the Great Hall and stop the Stone-Sickness for good."

"We will start pulling the wood for the second cabin at first light, Lord Jack," Giles promised, his voice thick with emotion.

"You have given us our lives back." Jack nodded, stepping out of the sweltering cabin and back into the freezing winter night.